How to Fix Common John Deere Electric Gator Problems?

The electric gator from John Deere has impressive features as a maintenance cart with 500 pounds capacity and runs by eight 6V batteries. You can use it as a golf cart or run in a safari park. If your incredible machine is not running correctly, you need to identify the John Deere electric gator problems and look for possible solutions quickly.

The usual problems with an electric John Deer gator are sudden power loss, failure to start, and continuous battery drain. You can also face slow movement or poor performance, hard-to-gear shift, cold weather effects (completely freeze, not moving an inch), etc.

You can solve these problems by checking out the power cords, battery voltage, electric connections, changing the battery if it’s too old, and reading the starting procedure manual. Let’s get into the details.

Quick Table for John Deere Electric Gator Problems, and Solutions

Are you getting bored looking into detailed information about your John Deere electric gator’s problems, symptoms, and solutions? Have a look at this short table with all the things you need to know. But don’t forget to check on the details later!

ProblemsShort solution
1. Sudden power loss● Check the electrical connections
● Check the battery connections
● Check battery charge
● Check the ignition bar
2. Failed to start● Check and repair the electric connections
● Replace the damaged battery
● Check the fuse and spark plugs
3. Slow move● Clean the clogged fuel filter
● Check and repair power cords
● Check the battery charge
4. The battery is not charging● Repair the power cords
● Replace the charger
● Check battery connections for rust
5. Hard to shift● Clean the clogged basket
● Add some glue/ lubricant to the primary
6. Cold weather effect● Maintain the choke position and crank
● Give additional seconds before cranking
● Repeat the cycle until it starts
● Turn on the tractor lights before cranking
7. Continuous battery drain● Replace the old or damaged battery
● Check for loose electrical connections

7 Common Problems with John Deere Electric Gator and Their Solutions:

An automobile comes with many problems. Some of them are simple and can be handled within a minute. Some of them are a pretty serious issues and often occur.

Here are some of those common problems of a John Deere electric gator:

1. Sudden Loss of Electric Power

Suppose you were riding your electric gator and had a sudden power failure. Tried to start again, and it ran but failed after a few seconds. Irritating, right!

Symptoms:

Such sudden power loss is easy to spot. You will notice the signs within a minute. Just observe for a bit these facts:

  • Power loss all of sudden
  • The battery is showing remaining charge but still power loss
  • Again power failure after several tries to run the engine

Reasons:

It’s better to identify the reasons for such sudden power loss rather than trying to run the engine after several failures. Here are causes of power loss:

  • Loose electrical connections
  • Loose battery connections
  • Rust on the battery plugs
  • Not enough charge to go on
  • Insufficient ignition

Solutions:

Don’t try to start the engine again if you don’t solve the issue. Check for the solution immediately.

  • Check the electric connections and repair them
  • Check the power cords of battery connections
  • Remove the rust and replace the rusted parts
  • Charge the battery for a while and then try again
  • Check proper ignition from the manual

2. Failed To Start

Failed to start the engine again and again! That’s another problem which mainly occurs with the old electric gators. If you are a victim of that, act accordingly.

Symptoms:

You won’t have to struggle to find the signs of a failed start. Here’s how:

  • Can’t start the engine with a charged battery
  • Too much struggle is even giving a result
  • No activity in the engine

Reasons:

That’s no shock that you have failed to start the engine multiple times. But you need to find out the reasons without any delay. Here are the possible explanations:

  • Rust in the battery connections
  • Damaged power cords
  • Old battery
  • Something wrong with the ignition
  • Damaged fuse
  • Loose spark plugs

Solutions:

You can’t use your electric gator if it doesn’t start. So, you need to solve the problems regarding failure to start. Here’s how:

  • Repair the rusts from battery connections
  • Replace the old battery
  • Check the power supply and voltage
  • Check the ignition interlock system
  • Repair the fuses

3. Slowly Moving

You start the electric gator to go on a ride in your golf cart but suddenly notice that it’s moving too slowly than usual. Did you charge the batteries last night or something else?

Symptoms:

Without following the signs, you can’t take the necessary measures. However, there are some obvious indications of poor performance like

  • Gator is moving at a slow speed than usual
  • Speed increment is not affecting the performance

Reasons:

Such poor performance will waste your time if you continue to use your electric gator. Here are some reasonable explanations:

  • Dirty cord connections
  • Insufficient charge in the batteries
  • Damaged batteries
  • Bad fuse

Solutions:

It will damage your engine if you continue to use your gator with such poor performance. So, do whatever is necessary.

  • Replace the fuses
  • Check the battery charge before taking a run
  • Replace the batteries after the lifespan is over
  • Clean the cord connections once a week

4. Battery Is Not Charging

Want to charge your battery, but something’s wrong! The battery is not taking charge. Well, it’s a pretty serious issue.

Symptoms:

It’s not much of a common problem unless you have an old battery. So check out the signs and observe precisely.

  • Not charging while plugged in
  • No charge reduction even if you use it for a while

Reasons:

When something is wrong with the battery, the problem can become a more significant issue if you don’t locate the reasons.

  • Loose power cord
  • Defective charger
  • Loose connection between charging cable and battery connector
  • Damaged battery and not usable further

Solutions:

Don’t stop just after finding the causes. You need to prepare the solutions according to each category.

  • Check the power cord for loose connections
  • Check the charger and the voltage with a voltammeter
  • Replace the battery if it’s damaged

5. Hard To Shift Gears

New electric gators don’t show such problems. However, if it’s a hard-to-shift problem, it’s not wise to run the gator until it’s fixed.

Symptoms:

It’s so common that most people don’t even acknowledge the problem and drive their gator without fixing it. Here’s how you will know:

  • Struggle with the shift during turning or changing speed
  • Doesn’t move the shift at all, no matter how hard you try

Reasons:

Well, there are quite a few reasons that cause hard-to-shift problems. So, you need to find them first. Here are the categories:

  • Clogged basket in the primary clutch
  • No sliding on primary clutch due to lack of lubrication

Solutions:

It’s dangerous to drive an electric gator when it has a hard shift problem. You can’t adjust speed when there’s any turn. Here’s how to fix it:

  • Adjust the primary and secondary clutch
  • Check whether the pressure belt is damaged or not
  • Add some lubricant to slide properly

6. Cold Weather Effect

This problem mainly occurs when you are in a cold region. Even if you drive your John Deere electric gator regularly, the cold weather may affect the engine.

Symptoms:

Usual problems like this happen in cold weather and have specific symptoms over the machine like

  • Low RPM
  • Engine’s freeze
  • Not starting even with proper ignition timing

Reasons:

It doesn’t matter whether you are a new or old resident of a cold region. To deal with this chronic problem, find the cause first.

  • The lever is not in the full choke position
  • Doesn’t provide enough time to crank the engine
  • Not heating the battery first

Solutions:

You can’t just sit around when finding those causes. Act on the issues if you want to drive your gator in the winter.

  • Keep the lever in the full choke position
  • Give enough time to crank the engine
  • Repeat the crank and ignition cycle 4 to 7 times
  • Keep the engine light on to heat up the batteries

7. Continuous Battery Drain

This is not an issue to be overlooked. No matter how many times you charge the batteries, this problem won’t disappear.

Symptoms:

There are only some apparent symptoms of quick battery drain, and you can’t ignore them

  • Low battery backup
  • Need to charge several times for a 4 to 5 hours operation

Reasons:

You need to identify the reasons as soon as you can, or else there will be several problems with the engine.

  • The battery is too old
  • Low-grade battery
  • Change the battery, but with poor connections
  • Rusty power cords

Solutions:

Want to avoid other hassles rather than the battery draining issue? Then act quickly to solve it.

  • Check the battery performance and voltage
  • Don’t buy low-grade batteries
  • Never use old cables

FAQs.

How to charge my John Deere gator battery?

First, you need to plug the power adapter or charger into the outlet. Check the power supply. Hold the charger connector and battery connector side by side. Then, slide the outer cap with opposite exterior openings until the connectors click to signal the secure connection.

You need to pinch the tabs inward and slide them out to unplug the battery.

What’s the cost of a John Deere electric gator?

A mid-range electric John Deere gator with a power box to lift, a winch, front brush guard may cost $13000. With some advanced features, the price might go up to $25599, though the tested price is $29408.

This cost differs based on the number of wheels, battery capacity, and add-on features.

How can I start my John Deere gator?

To start your John Deere gator, you need to first put on the seat belt. Then check the traction lock, shift lever, and parking brake. Put and hold the choke, which is under the seat.

Put the ignition key and turn it clockwise. When the engine starts, release the choke and the key. Allow for idling and move the shift lever.

What are facts to know before buying a John Deere gator?

You need to consider some facts while buying an electric John Deere gator, like terrain, power source, hauling capacities, number of passengers, and speed.

You won’t be able to utilize your John Deere electric gator if you don’t consider these facts. Sudden add-on passengers might leave a heavy load on your gator, and slow speed might kill your time.

Conclusion

Using a John Deere electric gator is environment-friendly and cost-efficient. It has zero emissions with enough backup for operations. The engine doesn’t even produce much noise.

However, no automobile is perfect and hundred percent efficient. We have discussed John Deere electric gator problems and effective ways to solve them. Hopefully, you can act accordingly whenever you notice such issues!

Related Posts: